replies Archived Message
Posted by Tony Sefton on September 13, 2006, 8:47 pm, in reply to "Re: Renault megan 1.9 turbo diesel s reg 1999 old engine"
Hi John. The fault with the starter motors is caused due to arcing where the brushes contact the communtator, The ones that we have done have all had around 80-100,000 miles and had oil contamination. And when they are stripped down, you can actually see a bad spot on the communtator where the brushes don't touch properly. We have reconditioned the starter motors ourself to prove exactly what causes the problem. ( rather than just accepting that a faulty starter motor causes the problem ) And all that is normally required is for the commutator to be machined up, a new set of brushes, etc. But normally for good measure a new solenoid is fitted and sometimes a new drive. H.T.H.
|
Message Thread:
- Renault Megan 1.9 turbo diesel s reg 1999 old engine - Non starter, no flywheel sensor signal - John enticott September 12, 2006, 6:31 pm
- replies - Sean Mc Gettigan September 12, 2006, 8:43 pm
- replies - John enticott September 12, 2006, 9:37 pm
- replies - NigelBennett September 12, 2006, 8:44 pm
- replies - Tony Ludford September 12, 2006, 10:14 pm
- replies - Sean Mc Gettigan September 13, 2006, 8:32 am
- replies - Tony Ludford September 13, 2006, 2:01 pm
- replies - Sean Mc Gettigan September 13, 2006, 5:14 pm
- replies - John enticott September 13, 2006, 8:09 pm
- replies - John enticott September 13, 2006, 8:11 pm
- replies - Tony Sefton September 13, 2006, 8:47 pm
- replies - Sean Mc Gettigan September 13, 2006, 10:16 pm
- fixed - FIX FIX FIX ............ September 14, 2006, 5:08 pm
- replies - Sean Mc Gettigan September 14, 2006, 5:54 pm
- replies - Tony Sefton September 15, 2006, 8:41 am
|
|